1971 Suzuki T500 stalling at idle and throttle release

Need some help? Put your question up here. Many years of experience on the board to help you get up and running.

Moderators: oldjapanesebikes, H2RICK, diamondj, Suzsmokeyallan

Post Reply
Stella1971
Still in the Driveway
Posts: 1
Joined: Tue May 07, 2013 11:57 am
Country: USA
Suzuki 2-Strokes: 1971 T500 2-stroke

1971 Suzuki T500 stalling at idle and throttle release

Post by Stella1971 »

My bike was converted into a beautiful cafe racer. The engine is actually a '75 2 stroke. I cleaned the carbs and repaired a float last year. The bike runs great as long as the throttle is engaged. I can't let off the throttle when slowing to turn or stop because it will stall. This is a pain because it is a kick start. I have tried to adjust the idle on each carb to no avail. I also put in a new battery. Any ideas as to what the issue could be?
titan performance
Expert racer
Posts: 1306
Joined: Wed Oct 13, 2010 2:55 pm
Country: England
Suzuki 2-Strokes: TS100, T200, GT250, T500, GT500, GT550, GT750, GS750
Location: Southeast England
Contact:

Re: 1971 Suzuki T500 stalling at idle and throttle release

Post by titan performance »

Hi Stella....so your bike is a 1975 T500 with 32mm Mikuni carbs is it? You say you have tried to adjust the idle on each carb to no avail. This seems strange to me, as screwing in the idle adjusters has to increase engine speed...as you are doing the same thing as opening the throttle.

A very common mistake which is made when these bikes are taken apart, is putting the slides back into the wrong carbs. The bike will run like this, but it wont idle, it will use a lot of gas, and the idle adjusters will have no effect.
Unscrew the top of one of your carbs, and pull out the slide....the cutaway must face the rear of the bike, if it does not, pull the other out, turn them round, and put them back in the opposite carbs.
Keeping old 2 strokes alive !
User avatar
tz375
Moto GP
Posts: 6211
Joined: Mon Nov 03, 2008 10:47 am
Location: Illinois

Re: 1971 Suzuki T500 stalling at idle and throttle release

Post by tz375 »

It could be almost anything from clogged piolt jets, slides in back to front at Triton suggested, timing, low compression, carbs out of synch, and so on.

I'd strip and rebuild the carbs (again) as a starting exercise and then go on to give it a complete service and check up. When you put teh crabs back together check the slides to make sure they are in the correct sides and are lifting together at exactly the same time.
User avatar
Coyote
Moto GP
Posts: 3404
Joined: Tue Oct 21, 2008 2:41 pm
Country: USA
Suzuki 2-Strokes: GT550x2, GT750, GS1000
Location: Tulsa, Oklahoma

Re: 1971 Suzuki T500 stalling at idle and throttle release

Post by Coyote »

It could be almost anything from clogged piolt jets
That would be the first place I would look - especially if you are using ethanol blended fuel. The ethanol likes to congeal and plug up the tiny holes in the pilot jets. Happened to me.
I was born with nothing and still have most of it left.

.
1978 GS1000C
1976 GT550 ongoing money pit.
Post Reply