Sundial Moto Sports

Gt 550 Cold start Problem
Page 2 of 2

Author:  sportston [ Sat Sep 14, 2019 4:27 pm ]
Post subject:  Re: Gt 550 Cold start Problem

Alan H wrote:
In that case, sack the battery and fit a Motobatt. Mine goes off the battery every time, first time.
It has to because I fitted a cover over the end of the kickstart shaft so it can't be used.

:wth: That's all very good, but not everyone is fit enough to bump start her if the battery goes flat. We can't all be fine specimens of manly physique like you Al. :wink:

Author:  Alan H [ Sat Sep 14, 2019 5:02 pm ]
Post subject:  Re: Gt 550 Cold start Problem

Never needed to. Just hit the button and away she goes. At a fit 68 I don't do bump starts any more!
More pics in the thread soon when I get the 'new' engine in after the crank rebuild.
Outer right seal went awol, and during crankcases split, found the gearbox bearings were shot.
Fortunately I had/have spare engines, so fitting a new box was easier than sourcing new bearings.
Should get the motor back this week.
Motobatt is charged and ready for action.

Page 2 of 2 All times are UTC - 6 hours
Powered by phpBB® Forum Software © phpBB Group