Learn Me GT380s

General discussion about Street two-stroke Suzuki motorcycles.

Moderators: oldjapanesebikes, H2RICK, diamondj, Suzsmokeyallan

Vintageman
Expert racer
Posts: 1483
Joined: Tue May 18, 2010 5:38 pm
Country: USA
Suzuki 2-Strokes: Suz, Yam, Honda, Kaw.
Location: New Hampshire

Re: Learn Me GT380s

Post by Vintageman »

Craig380,

I think you said you measured straight across in the cylinder. I did a paper trace then laid the paper flat. So I was thinking that is why mine shows longer.

Is that true

For a paper trace I covered just the port I wanted so I could tape it in place on the cylinder wall so it won’t move. Them just use a soft pencil.

Update: Oops I did mess up the exhaust numbers as I looked again. repeated intake

I accidently found if you take tape (I used a black duck tape like stuff) and put it in the cylinder and rub over port and top of liner with your fingers it make a perfect sharp line in glue to measure from
Exhaust:

Top 1.280”/32.5mm 1.295”/32.893mm
Bottom 2.173”/55.19mm
Width 1.574”/39.98mm 1.426”/36.22mm widest

Intake:
Top 2.572”/65.33mm
Bottom 3.340”/84.84mm
Width 1.574”/39.98mm across both windows

Transfer:
Top 1.667”/ 42.34mm
Bottom 2.217”/56.3mm * Tried to exclude long factory chamfering
Width` 1.260”/32mm
Current Bikes
74 GT250 (T350 upgrade),
76 GT250 (T350 upgrade),
71 T350,
70 T350,
74 GT380,
75 T500,
73 GT550,
75 GT750,
72 Yamaha DS7 (R5 upgrade),
77 Yamaha RD400 (Daytona Cyls),
User avatar
markush
On the main road
Posts: 195
Joined: Thu Oct 03, 2013 4:39 am
Country: Germany
Suzuki 2-Strokes: GT250/380
Contact:

Re: Learn Me GT380s

Post by markush »

Hi !
I took some values, too.
Some are equal as posted above, some are different.
All my cylinder ports were in stock condition.
Bore 54,5mm, all.
all measures in mm.
width = chord (not circumferential).
Distances from cylinder top surface.

GT380B
average values of 3 cylinders. (one set of Left+Center+Right)
Outlet
width : 33,7
top : 33,4
bottom : 56,2
(heigth : 22,8)
Inlet
width: 36,8 (over all)
(center bar width : 4,5)
top : 65,5
bottom : 84,4
(heigth : 18,9)
transfers (measure for one)
width : 27,5
top : 43,4
bottom : 56,4
(heigth : 13)


GT250L/M
Shown values are averages of 4 cylinders. (two sets of Left+Right)
The range off differences between cylinders was max. 1 mm.
Outlet
width : 33
top : 32,5
bottom : 54,5
(heigth : 22)
small additional Outlets (measure for one. Lying at the same heigth/position as transfer ports)
width : 6
heigth : 12
Inlet
width: 36 (over all)
(center bar width : 3)
top : 66,8
bottom : 84,7
(heigth : 17,9)
transfers (measure for one)
width : 26
top : 43,3
bottom : 55,3
(heigth : 12)

Shapes of outlet ports of 250/380 are a bit different.
Auslassschlitz_GT250_380_dr.jpg
You do not have the required permissions to view the files attached to this post.
Post Reply